intTypePromotion=1
zunia.vn Tuyển sinh 2024 dành cho Gen-Z zunia.vn zunia.vn
ADSENSE
 » 
 » 

Báo cáo nghiên cứu khoa học: "ĐỘNG CƠ SỬ DỤNG PHỐI HỢP NHIÊN LIỆU BIOGAS -XĂNG "

Chia sẻ: Nguyễn Phương Hà Linh Nguyễn Phương Hà Linh | Ngày: | Loại File: PDF | Số trang:9

Thêm vào BST
Báo xấu
90
lượt xem 13
download
 
  Download Vui lòng tải xuống để xem tài liệu đầy đủ

Tuyển tập những báo cáo nghiên cứu khoa học hay nhất của trường đại học Đà Nẵng đề tài: ĐỘNG CƠ SỬ DỤNG PHỐI HỢP NHIÊN LIỆU BIOGAS -XĂNG...

Chủ đề:

Bình luận(0) Đăng nhập để gửi bình luận!

Lưu

Nội dung Text: Báo cáo nghiên cứu khoa học: "ĐỘNG CƠ SỬ DỤNG PHỐI HỢP NHIÊN LIỆU BIOGAS -XĂNG "

  1. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 BIOGAS-GASOLINE HYBRID ENGINE ĐỘNG CƠ SỬ DỤNG PHỐI HỢP NHIÊN LIỆU BIOGAS -XĂNG BUI VAN GA - LE MINH TIEN TRUONG LE BICH TRAM TRAN HAU LUONG Da Nang University ABSTRACT A biogas-gasoline hybrid engine converted from a 2HP spark ignition engine is used in the study. The engine is supplied by gasoline at starting and idling regimes. Full power of the engine is given by biogas combustion. Engine speed is controlled automatically by a double regulator which activates the biogas valve and mixture valve simultaneously. The relationship between the motions of the two valves has been proposed. 3 The engine consumes about 1m biogas to produce 1kWh electricity and reduce 1kg CO2 emission in the atmosphere. CO and HC emission amount is reduced by more than 60% when the engine runs on biogas in comparison with gasoline case. The new concept of double regulator allows a good stabilization of output voltage of the generator. The voltage fluctuation is less than 5% of the normal output voltage value. TÓM TẮT Thí nghiệm sử dụng động cơ phối hợp nhiên liệu biogas-xăng được cải tạo từ động cơ đánh lửa cưỡng bức 2HP. Khi khởi động và chạy không tải, động cơ sử dụng xăng. Khi kéo tải động cơ chuyển sang sử dụng biogas. Tốc độ động cơ được khống chế một cách tự động nhờ bộ điều tốc hai chức năng, tác động đồng thời lên van tiết lưu biogas và van hỗn hợp. Mối quan hệ chuyển động của hai van này đã được thiết lập. 3 Động cơ tiêu thụ khoảng 1m biogas khi sản xuất được 1kWh điện và góp phần giảm được 1kg CO2 thải vào khí quyển. Mức độ phát thải CO và HC cũng giảm hơn 60% khi động cơ chạy bằng biogas so với khi chạy bằng xăng. Bộ điều tốc hai chức năng cho phép ổn định tốt tần số điện của máy phát. Điện áp đầu ra của máy phát chỉ dao động khoảng 5% giá trị điện áp định mức. 1. Introduction Energy is one of the world’s most critical issues in the 21st century. As fossil fuel resource is depleting rapidly, energy security has become more sensitive in international affairs. Continuing increase in crude oil price in recent years (over 145USD/barrel in July 2008) poses threads to the stability of the world’s economy, particularly the economies in developing countries. On the other hand, air pollution caused by burning fossil fuels (coal, oil, and natural gas...) have caused impacts on human beings and the environment for decades. Combustion product contains pollutants that are very harmful to human health such as carbon monoxide (CO), hydrocarbons (HCs), nitrogen oxides 40
  2. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 (NOx), sulfur oxide (SO2), soot etc. Especially carbon dioxide (CO2), the main product of combustion, is a green house effect gas that significantly contributes to global warming. A lot of international efforts and initiatives has been made to reduce greenhouse effect gas emissions for controlling the phenomenon of climate change. ASEAN member countries have commitments to implementation of Kyoto Protocol under UN Framework Convention on Climate Change and are already making steps towards emission reductions, particularly through Clean Development Mechanism. The utilization of sustainable and renewable energy is apparently an effective measure to achieve CO2 emission reduction targets and combat with the global warming. Research on using of renewable energy as an alternative source of energy has captured attention of scientists for decades, especially since the world’s oil crisis in 1973. Biogas, a neutralizing CO2 fuel, has double interest: energy saving and environment protection. Biogas is a product of decomposing organic substances in anaerobic conditions. Organic substances can often be plants (trees, straws etc.) or animals (animal wastes, by-products from food processing…), and wastes from breeding. CO2 generated by burning biogas will be absorbed by new plants; therefore, CO2 amount in atmosphere will be balanced. There are two main sources of biogas produced: one from biogas digesters (tanks) and the other from the organic substance fermentation under anaerobic conditions in landfills. Biogas contains mainly CH4 (50-70%) and CO2 (25-50%) and other impurities such as H2S. If biogas is refined from impurities, we will have a fuel with the same properties as natural gas. Developed countries such as USA, France, Germany, Denmark etc use biogas from landfills to generate electricity. In developing countries, biogas production technology for household use has become popular, particularly in India, China and ASEAN countries. In the meantime, developing countries has also piloted or employed technologies of utilizing biogas form landfills for power generation. Over the past ten years, energy from biogas has become widely used in Viet Nam. Biogas production processes have been improved to achieve higher efficiency. Traditional biogas tanks (digesters) built with bricks and concrete often corroded by acids, which causes gas leakage problems. Recently, super durable composite biogas tanks to overcome such problems have been manufactured. This new type of digesters made of composite material is resistant to acid corrosion, and thus can avoid gas leakage. Especially with composite tank, it requires lesser time for installations. This kind of tanks is welcomed by many farmers thanks to its higher effectiveness. Else where in Viet Nam, biogas production technologies have been well developed. Many projects supported by international funds has significantly contribute to success of biogas applications across the country. In 2006, a collaboration project on biogas production between Viet Nam and Netherlands was awarded the Environment Prize of the United Nations. 41
  3. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 Today, the utilization of energy from biogas has helped in dealing with major issues related to environment protection and energy use in rural areas where more than 80% Vietnamese population live. At present, biogas is used mostly for cooking. Direct combustion is the simplest method of biogas energy utilization. However, the growing demand for household energy further pushes up the development of biogas utilization in producing power for working machines used in argo-based industries such as pumps, mills, regrigerators. Development and applications of technologies to use biogas as a fuel for small power internal combustion engines will make an important contribution to meeting the demand for power, raising income and protecting local environment in rural areas of Viet Nam. In the previous works, we have presented the results of our research on spark ignition fueled by biogas [10]. The biogas-diesel dual fuel engine has been also presented by our recent paper [11]. This work will focus specially on a new concept of fuel supplying system to biogas-gasoline hybrid engine. 2. Theoretical modeling The combustion of hydrocarbon in general can be expressed by the following model: 1 H2  H ; 2 1 H 2 O  OH  H 2 2 1 O2  O ; 2 CO2  H 2  H 2O  CO 1 N2  N ; 2 1 H 2O  N 2  H 2  NO 2 Fig. 1: Cross section of 2H2O  2H2  O2 the 2HP engine The combustion product is assymed in thermodynamique equilibrum state. The application of the model in combustion chamber of engine requires law of flame propagation. We suppose that the flame front is spheric and it is deformed due to the combustion chamber wall. The two-zone model [3] has been applied here to calculate the combustion in combustion chamber. The mixture and the combustion product are separated by flame front. The thermodynamic state of fluid in combustion chamber is represented by following equation system: 42
  4. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 Vp Tp Tp Tm Q V p p V T  cvm  p p R  p m  R m ; Vp ; Vm cvp           The calculation is applied p(bar) to a 2HP engine whose Gasoline 25 compression ratio is 7.6 (fig. 1). Biogas The bore and the stroke of the 20 engine are respectively 51mm and 42mm. Figure 2 shows 15 comparison of variation of combustion pressure in cylinder 10 when the egine is fueled by 5 gasoline and by biogas. With () biogas containing 80% CH4, the 0 -200 -160 -120 -80 -40 0 40 80 120 160 200 maximal combustion pressure is Fig. 2: Comparison of combustion pressure about 10% lower than that of given by gasoline and biogas fuels gasoline case. Figure 3 presents the variation of pressure in combustion chamber with different concentration of CH4 in biogas fuel. The result shows that the maximal pressure increases 10% when the p(bar) 80% CH4 25 70% CH4 CH4 in biogas changes from 60% 60% CH4 (crude biogas) to 80% (purified 20 biogas). When CH4 concentration is higher than 60%, biogas can be 15 applied directly to engine. In some biogas digester, CH4 10 concentration is lower than that value. In this case, the combustion 5 in low load regime is very poor () 0 and it is very difficult to start up -200 -160 -120 -80 -40 0 40 80 120 160 200 the engine directly by biogas. Fig.3: Effect of biogas quality on combustion Thus biogas-gasoline hybrid pressure engine is the best way to solve the problem. 3. Experimental set up and results Our the research on different biogas sites shows that the engine consumes approximatively 1m3 biogas to produce 1kWh electricity. The continuous operation time of generator depends on capacity of biogas production of the installation. Most of biogas degesters in our countries actually use wastes of animals, particularly that of pigs in farms. The daily time of continuous operation of generator in function of pigs number is shown in the table 1. The use of biogas as a fuel for engines requires firstly treatment of produced gas to remove 43
  5. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 impurities (known as biogas filtration), of which H2S and CO2 are major substances. Figure 4 presents the picture of an experimental compact biogas filtration system. - H2S removal process: To remove H2S from biogas stream, simple method of adsorption by iron oxides is employed [1], [2]. In preparation of iron oxides as adsorbent, ion scraps Table 1: Daily time of continuous operation of generator in function of pigs number in farm Output Number of pigs power 20 50 100 150 200 300 400 500 (kW) 1 3 8 16 24 2 1,5 4 8 12 16 24 3 1 2,5 5 8 10 16 21 4 2 4 6 8 12 16 20 5 3 5 6 9,5 12 16 6 4 5 8 10 13 7 3,5 4,5 7 9 11 8 3 4 6 8 10 9 3,5 5,5 7 9 10 3 4,5 6,5 8 11 4,3 6 7 12 4 5,2 6,5 13 3,5 5 6 14 4,5 5,5 Fig. 4: Compact H2S-CO2 15 4 5 filtration system 3 4 1 5 2 are pre-treated by oxidization to form the coated iron oxides layer. The formed iron oxides are the mixture of FeO, Fe2O3, Fe3O4. Pre-treated iron scraps are Gas vào mixed up with wooden scraps and sawdust in the ratio 1:1 and then loaded into an Giảm tải Tăng tải adsorption vessel. With the diameter of 0.2m Cần điều khiển and height of 1.5m, a PVC vessel is capable từ bộ điều tốc of containing 8 kg adsorbing material and processing 0,86 m3 biogass per hour. Averaged pressure loss through the H2S removal column is about 0.3mbar during operation [6]. - CO2 scrubber: Liquids with increased solubility for CO2 are typically chosen over water in CO2 scrubbing process, but the principal Fig. 5: Principle of power control of biogas/gasoline hybrid engine advantages of water as an absorbent are its 44
  6. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 availability and low cost. Absorption of acid gas by water produces slight corrosive solutions that can be harmful to equipment if not controlled. CO2 and water countercurrent contact with each other in a scrubber. A neutral material layer consisting of brickbats, woodchips and gravels as a packed column is fitted into the scrubber by a perforated plastic sheet to intensify the gas-water contact. In our experiment, the scrubber operates at biogas flow rate of 0.86 m3/h, CO2 concentration at inlet is 36.47%, and 19.22% at outlet of biogas stream. CO2 removal efficiency reaches 47.30%. Pressure drop through the packed column is about 5mbar [6]. - Biogas supplying system for biogas-gasoline hybrid engine 50 The principle of filling of biogas- 45 10 15 gasoline hybrid engine is presented on figure 5. The main gasoline injector closed. M13x1,5 M18 M10 25 7 M13x1,5 The gasoline system supplies only the idling injector. Biogas is supplied to the engine via 18 the flow control valve (Fig. 6). The 35 regulator has double action. It commands 110 simultaneously biogas valve and mixture 32 1,5 lỗ 1 valve. At starting up and idling regime, the 2 lỗ 3 7 9 3 engine is fueled by gasoline. When the load 3 3 is increased, the butterfly mixture valve is 38 opened, vacuum at idling injector is Fig. 6: Design of biogas control valve decreased so that gasoline injection is stopped while biogas valve is opened gradually: the engine turns to run on biogas. With this system, the engine can be started easily and it can be stable at idling regime particularly with poor CH4 biogas fuel. The ratio of displacement of conic needle of biogas valve l and rotation of mixture butterfly valve  is calculated via the relationship (fig. 7): So  Sv sin  1  C p B m  . C p m B  2    2  d   d  ltg   4 2     Where So, Sv are respectively Biogas  d areas of admission hose and that of Regulator butterfly valve plate;  is equivalent l ratio of the mixture; C is stoechiometric mass ratio between biogas and air; m Mixture  Air and B are respectively densities of S mixture and biogas; pm and pB are o S v respectively upstream-downstream Fig. 7: Relationship between motion of pressure differences of mixture valve mixture valve and biogas control valve 45
  7. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 and of biogas valve; d is diameter of biogas valve; is angle of needle. The diameter of injector is calculated approximately in function of biogas consumption. According to our experiments, the relationship between biogas flow, supplying pressure and injector diameter can be given by following expression: Q  K.d 2 p Q: Biogas flow (m3/s) Where d: Diameter of injector (m) p: Biogas pressure in storage bag (N/m2) K: Constant The result of our research shows that the constant K=0,45. The generator supplies to a load panel constituted by 500W electric bulbs (fig. 8a and fig. 8b). The result is shown on figure 9. After starting up, the engine runs in idling regime with indicated output voltage of the generator is about 40 volts. By increasing of acceleration spring tension, output voltage 220 volts is obtained. The engine turns now to run on biogas. When we switch on or switch off the 500W bulbs, the fluctuation of voltage is less than 5% normal voltage. It satisfies the requirement of electricity production quality. The emission level of the engine was also compared in cases the engine fueled with gasoline and with biogas. The pollution measured results in the two cases are shown in figure 10. Measurements were carried out in the variant load modes. Results showed Fig. 8: Load testing of a very small amount of pollutant concentration in biogas/gasoline hybrid engine exhaust gas when engine runs on biogas Switch off 500W Loading, biogas 250 (about 0,07% of CO and 30ppm of U(V) HC) in the critical regimes making a 200 great reduction of 78% for CO and 60% Switch on 500W for HC in comparison with gasoline 150 case . - Economy and environment 100 impacts 50 The engine consumes about 3 Idling, gasoline 1m of biogas to produce 1kWh of t(s) 0 electricity. The 1kW generator engine 0 50 100 150 200 consumes 5 liters of gasoline in 10 Fig. 9: Output voltage variation hours. If it runs 10h/day on biogas, the in function of load regime 46
  8. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 owner can save 2 millions VND/month or 24 millions VND/year. If we use 10,000 similar biogas engine groups, we can save 240 billion VND per year. CO2 emission of combustion gasoline fuel is 2.31kg/liter. The above 1kW generator gasoline engine runs 10h/day emits 11.55kg CO2 per day or 3.5 tons CO2 per year. Thus the production of 1kWh electricity by biogas will contribute to the reduction of 1kg CO2 emission. So, if the engine runs on biogas, we can reduce CO2 emission about 3.5 ton per year. If we use 10.000 similar biogas engine groups, we can reduce 3 5.000 tons of CO2 emission per year. This is a considerable contribution to global warming mitigation. HC(ppm) 280 10 CO(%) 8 210 6 140 4 70 2 Power(W) 0 Power(W) 0 0 200 400 600 800 1000 0 200 400 600 800 1000 Figure 10: Comparison HC and CO concentration in exhaust gas of the 2HP biogas-gasoline hybrid engine fueled by gasoline and by biogas 4. Conclusions  Biogas is great potential energy in the rural areas of Vietnam. The use of this kind of energy will be an important contribution to resolving of energy-environment problem of the country.  Biogas-gasoline hybrid fuel supplying system is an appropriate way to apply poor biogas on spark ignition engine.  For producing 1kWh electricity, the biogas-gasoline hybrid engine consumes about 1m3 of biogas and it contributes to the reduction of 1kg CO2emission.  Double action regulator can provide good stabilization of engine speed. Output voltage fluctuation of generator is less than 5% of normal voltage Acknowledgement: The present research is partially funded by the National Fundamental Scientific Research Program. REFERENCES [1] Hydrogen sulfide removal from anaerobic digester gas. Agricultural Wastes, Volume 11, Issue 3, 1984, Pages 167-179. 47
  9. TẠP CHÍ KHOA HỌC VÀ CÔNG NGHỆ, ĐẠI HỌC ĐÀ NẴNG - SỐ 3(26).2008 [2] Biogas Utilization Handbook, published by the Environment, Health and Safety Division, Georgia Tech Research Institute, Atlanta, Georgia, 1988. [3] BUI VAN GA, TRAN VAN NAM, LE VAN TUY: Numerical code for combustion calculation in spark ignition engines. Journal of Science and Technology, No 36+37/2002, pp. 131-137 [4] BUI VAN GA: Combustion: Modeling and experiment. Proceedings of Conference on 25th Anniversary of Mechanic Institute, pp. 38-44, Hanoi, 8-9 April 2004 [5] BUI VAN GA, NGO VAN LANH, NGO KIM PHUNG, VENET CEDERIC: Testing of biogas on motorcycle engine. Review Science and Technology, The University of Danang, No.1(18), pp. 1-5, 2007 [6] BUI VAN GA, NGO VAN LANH, NGO KIM PHUNG: Purification of biogas for fueling internal combustion engine. Review Science and Technology, The University of Danang, No 4-2007 [7] BUI VAN GA, TRAN VAN NAM: Combustion of LPG-Air Lean Mixture: A solution for pollution reduction of motorcycles in Vietnam. The 6th General Seminar of the Core University Program “Environmental Science and Technology for sustainability of Asia, Kumamoto, Japan, 2-4 October 2006, pp. 361-367 [8] BUI VAN GA: Patent 5940 “LPG/gasoline conversion kit for motorcycles" National Office of Intellectual Property, 2006. [9] NHAN HONG QUANG: bi-fueled reciprocating engines - an effectively solution for renewable energy utility and environmental protection in the vietnamese rural areas.Journal of Science and Development No 127-2007, pp. 30-37, 2007 [10] BUIVANGA, TRUONG LE BICH TRAM, TRUONG HOANG THIEN, LE MINH TIEN: Biogas Supplying System for Small Power Engine. National Conference on Fluid Mechanics, Hue, 21-23 July, 2007 [11] BUI VAN GA, LE MINH TIEN, NGUYEN VAN DONG, NGUYEN VAN ANH: Biogas Supplying System for Biogas/Diesel Dual-Fuel Engine. Review Science and Technology, The University of Danang, No 3-2008 48
ADSENSE

CÓ THỂ BẠN MUỐN DOWNLOAD

LV.09: Bộ Luận Văn Tốt Nghiệp Chuyên Ngành Quản Trị Kinh Doanh
81 tài liệu
1643 lượt tải
THÔNG TIN
TRỢ GIÚP
HỖ TRỢ KHÁCH HÀNG
Theo dõi chúng tôi

Chịu trách nhiệm nội dung:

Nguyễn Công Hà - Giám đốc Công ty TNHH TÀI LIỆU TRỰC TUYẾN VI NA

LIÊN HỆ

Địa chỉ: P402, 54A Nơ Trang Long, Phường 14, Q.Bình Thạnh, TP.HCM

Hotline: 093 303 0098

Email: support@tailieu.vn

Giấy phép Mạng Xã Hội số: 670/GP-BTTTT cấp ngày 30/11/2015 Copyright © 2022-2032 TaiLieu.VN. All rights reserved.

 

Đồng bộ tài khoản
2=>2